A comparison of different pre-treatments to increase methane production from two agricultural substrates

To enhance the methane production from ensiled sorghum forage and wheat straw, thermal, alkaline and thermo-alkaline pre-treatments were performed in batch mode. Alkaline pretreatment was conducted at 40 degrees C for 24 h with the addition of 1% and 10% gNaOH/gTS; thermal and thermo-alkaline pre-treatments at 100 degrees C, and 160 C for 30 min, with and without the addition of NaOH solutions at the above dosages. All the pre-treatments tested led to a solubilization of the organic matter, with a maximum concentration (around 30-40% for both substrates) obtained at 40 and 100 C with 10% NaOH. Furthermore, a reduction in the fibrous fractions was observed for both substrates. The highest lignin reduction, compared to untreated samples, was found at 100 degrees C with 10% NaOH dosage (53% and 72% for wheat straw and sorghum, respectively). Under this pre-treatment condition a high hemicelluloses reduction yield was also found (63% for both substrates). The highest increase in methane yield (up to 32%), compared to the untreated substrate was observed at 40 degrees C with 10% NaOH for sorghum. As for wheat straw, significant increases in methane yield were observed at 40 degrees C with 10% NaOH (43%) and at 100 degrees C with 1-10% NaOH (48% and 67%, respectively). According to the results of the preliminary economic analysis, the pretreatments seemed to be sustainable for both substrates, especially for wheat straw, due to a higher methane yield increase than that of sorghum. (C) 2012 Elsevier Ltd. All rights reserved.